主要组成 Main composition | 该类漆由酚醛树脂，红丹防锈颜料、纳米材料及体质颜料经混合研磨后，加入催干剂，有机溶剂等调制而成。This kind of paint is made of phenolic resin, Hongdan antirust pigment, nano-material and body pigment after mixed grinding, adding drier, organic solvent and so on. | |
主要特性Main characteristics | 该产品可广泛用于车辆、船舶、桥梁、铁路、交通等户外大型钢铁结构作防锈打底之用，也可作要求不高的防锈表面涂覆，适用于黑色金属。 The product can be widely used in large outdoor iron and steel structures such as vehicles, ships, bridges, railways, transportation, etc., as well as rust-proof surface coating with low requirements, suitable for ferrous metals. | |
主要用途Main use | 自干型漆，漆膜具有较好的防锈性能，纳米材料的加入大大改善了涂层中颜料和填料的体积填充密度，减少毛细管作用，提高了涂层对腐蚀介质的屏蔽作用，因而大大提高了其防锈能力，比之纯红丹制防锈漆其防锈能力要好，通用性好但耐候性稍差。 The self-drying paint film has better antirust performance, and the addition of nano-materials greatly improves the volume filling density of pigments and fillers in the coating, reduces the capillary effect, and improves the shielding effect of the coating to the corrosion medium. as a result, its antirust ability is greatly improved, which is better than pure red antirust paint, good versatility but poor weather resistance. | |
技术指标Technical index | 外观Appearance | 漆膜外观正常，漆膜平整。 The appearance of the paint film is normal and the paint film is smooth. |
容器中状态 Status in container | 搅拌后无硬块，呈均匀状态。 After stirring, there is no hard lump, showing a uniform state. | |
施工性 Construction property | 涂刷无障碍 Painting barrier-free | |
细度，μm Fineness, μ m | ≤50 | |
干燥时间，h Drying time, h | 表干≤5，实干≤24。 The surface dry is ≤ 5, and the practical dry is ≤ 24. | |
对面漆适应性 Adaptability of face paint | 对面漆无不良影响 There is no adverse effect of face paint. | |
理论用量 Theoretical dosage | 150～250g/㎡，涂装次数：建议涂装二道，前一道干透后，才能涂下一道。 150~250g/ coating, painting times: it is recommended to apply two lines, and only after the first one is dry can one be applied. | |
涂装方法 Painting method | 可刷涂或者喷涂，使用前应将漆液充分搅匀，用配套稀释剂调整至施工粘度。 Can be brushed or sprayed, the paint should be fully stirred before use, with matching diluents to adjust to the construction viscosity. | |
配套用漆Matching paint | 各色酚醛调和漆、醇酸磁漆等。 Various colors of phenolic blending paint, alkyd enamel, etc. | |
表面处理 Surface treatment | 清除前道漆膜上的灰尘等所有污物，漆膜上无酸碱或水份凝结，被刷涂表面应干净、污水、无油污、无绣。Remove all dirt such as dirt on the front paint film, there is no acid, alkali or water condensation on the paint film, the surface to be brushed should be clean, sewage, no oil, no embroidery. | |
注意事项Matters needing attention | 使用前将漆充分搅拌均匀，底漆应干透才能涂面漆。 Stir the paint well before use, and the primer should be dry before you can apply the topcoat. | |
储藏期限 Storage period | 产品在规定储运条件下，漆料储存期为12 个月，超过储存期可按质量标准检验，如符合技术要求，仍可使用。Under the specified storage and transportation conditions, the storage period of paint is 12 months, which can be inspected according to the quality standard after the storage period. If it meets the technical requirements, it can still be used. | |
附注：本说明书有关数据是在标准条件下实验取得，实际使用时，因环境条件和施工方法的差异可能与之略有不同，以上数据如有改变，已本厂最新说明书为准，恕不另行通知。 Note: the relevant data in this manual are obtained by experiment under standard conditions. In actual use, they may be slightly different due to differences in environmental conditions and construction methods. If the above data are changed, the latest instructions of our factory will prevail without prior notice. | ||