主要组成 Main composition | 由氯化橡胶树脂、改性树脂、各色颜填料、助剂、有机溶剂等组成的单组份自干型涂料。 An one-component self-drying coating composed of chlorinated rubber resin, modified resin, various colors and fillers, auxiliaries, organic solvents, etc. | |
主要特性Main characteristics | 漆膜干燥快、坚韧、附着力好，具有良好的保护、装饰性能。 The paint film has the advantages of fast drying, tenacity and good adhesion, and has good protective and decorative properties. | |
主要用途Main use | 适用于室内外各种金属构件设备的装饰与保护。 It is suitable for decoration and protection of all kinds of metal components and equipment indoors and outdoors. | |
基本参数 Basic parameters | 漆膜外观 Appearance of paint film | 花纹清晰、美观、立体效果明显 The pattern is clear, beautiful and three-dimensional effect is obvious. |
粘度（涂-4 杯，25℃，秒） Viscosity (coating-4 cups, 25 ℃, seconds) |
≥150 | |
干燥时间 Drying time | 表干：≤0.5，实干：≤24。 Table dry: ≤ 0.5, practical: ≤ 24. | |
施工参考Construction reference | 以喷涂为主，使用前将漆液充分搅匀（不允许与其他不同性质、不同品种漆混合使用），如粘度太大，应用配套稀释剂调整，否则会影响施工质量，甚至造成报废（施工粘度以不流挂为好）。 Give priority to spraying, fully stir the paint liquid before use (it is not allowed to be mixed with other different properties and different kinds of paint), such as the viscosity is too high, the application of matching diluent adjustment, otherwise it will affect the construction quality, and even cause scrap (construction viscosity should not flow hang as well). | |
配套用漆Matching paint | 可用环氧酯底漆、环氧富锌底漆和各色环氧防锈底漆配套各色桔纹漆，一般底漆需要干燥48 小时后才能喷涂面漆，避免咬底。 Epoxy ester primer, epoxy zinc-rich primer and various color epoxy antirust primer are available. Generally, the primer needs to be dried for 48 hours before spraying the topcoat to avoid biting the bottom. | |
表面处理Surface treatment | 底材按 GB8623-88、SA2.5 级或 ST3 级处理，表面粗糙度 30～70μm。 The substrate is treated according to GB8623-88, SA2.5 or ST3 grade, and the surface roughness is 30 ~ 70 μ m. | |
注意事项 Matters needing attention | 1、不同批次，不同材质，不同施工条件都会引起桔纹漆花纹、色相产生微小差距，此特征为所有桔纹漆的正常现象。1. Different batches, different materials and different construction conditions will cause a small gap in orange pattern and hue, which is the normal phenomenon of all orange lacquers. 2、避免在烈日暴晒环境下喷涂或施工。 2. Avoid spraying or construction in the hot sun. 3、本产品为挥发自干型产品，施工剩余漆请立即盖好盖子或用少量溶剂盖面，以免干结。 3. This product is a volatile self-drying product. Please cover the lid immediately or cover it with a small amount of solvent to avoid dry knot. | |
储藏期限 Storage period | 产品在规定储运条件下，漆料储存期为12 个月，超过储存期可按质量标准检验，如符合技术要求，仍可使用。Under the specified storage and transportation conditions, the storage period of paint is 12 months, which can be inspected according to the quality standard after the storage period. If it meets the technical requirements, it can still be used. | |
附注：本说明书有关数据是在标准条件下实验取得，实际使用时，因环境条件和施工方法的差异可能与之略有不同，以上数据如有改变，已本厂最新说明书为准，恕不另行通知。 Note: the relevant data in this manual are obtained by experiment under standard conditions. In actual use, they may be slightly different due to differences in environmental conditions and construction methods. If the above data are changed, the latest instructions of our factory will prevail without prior notice. | ||